Call (973) 709-5323Call
White two-story colonial house with dark shutters behind a red maple in fall

HVAC Repair in Wayne, NJ

Boiler repair, furnace repair, heat pump repair and AC repair in Wayne and the towns around it. Emergency boiler repair when the heat goes out.

Call (973) 709-5323

Heating and Cooling Repair in Wayne, NJ

Wayne HVAC Service repairs boilers, furnaces, heat pumps, central air conditioners and ductless mini splits in Wayne and the towns around it: Totowa, Woodland Park, North Haledon, Pompton Lakes and Pompton Plains.

When a boiler stops heating, the cause is usually one part: a circulator pump, a zone valve, a low water cutoff, an expansion tank or the burner controls. When a furnace quits, it is usually an igniter, a flame sensor, a pressure switch or a blower motor. When central air fails in July, it is usually a capacitor, a contactor, a fan motor or a clogged drain.

Boiler out in freezing weather, or water on the basement floor? See emergency boiler repair.

Packanack Lake in Wayne, New Jersey with fall trees along the shore

Boiler, Furnace, Heat Pump and AC Services in Wayne

ServiceWhat gets repairedPage
Boiler RepairHot water and steam boilers: circulators, zone valves, low water cutoffs, burners, radiator ventsBoiler Repair in Wayne
Emergency Boiler RepairBoilers that will not fire, leak, overheat or sat in flood waterEmergency Boiler Repair in Wayne
Furnace RepairGas and oil furnaces: igniters, flame sensors, inducers, blowers, boards, oil burnersFurnace Repair in Wayne
AC RepairCentral air: capacitors, contactors, fan motors, frozen coils, leaks, attic drainsAC Repair in Wayne
Heat Pump RepairDefrost boards, reversing valves, iced coils, backup heat, dual fuel controlsHeat Pump Repair in Wayne
Ductless Mini Split RepairWall heads that leak, run without cooling or flash codes; outdoor unitsDuctless Mini Split Repair in Wayne

Wayne Houses and the Heat in Them

The median Wayne home was built in 1967, and about two thirds were built before 1980 (Census data for Wayne township). Gas heats about 87 percent of homes, through a hot water or steam boiler with baseboard or radiators or through a forced-air furnace. Homes heated by boilers have no heating ducts, so they cool with attic air handlers or ductless heads.

Lake cottages around Packanack Lake and Pines Lake were winterized for year-round living in the 1940s, and the farms between them were built over with subdivisions once the war ended (history of Wayne, New Jersey). Converted lake houses tend to have heat added in pieces; postwar houses are often on their second or third boiler or furnace, piped into the original radiators or ducts.

The nearest NOAA climate station, in Little Falls, records roughly five times as much heating demand as cooling demand in a typical year (NOAA 1991 to 2020 climate normals), so heating equipment runs from October into April and wears out igniters, pumps and motors. Air conditioners sit idle most of the year and fail in the first heat wave. Basements near the Passaic and Pompton rivers add flood damage to burners and controls.

Service Area Around Wayne

All of Wayne, including Packanack Lake, Pines Lake, Preakness, Mountain View and Pompton Falls, plus these nearby towns. The Wayne service area page covers each one.

TownHousing and heat
TotowaOlder houses than Wayne: median build year 1958
Woodland ParkApartments, condos and houses below Garret Mountain
North HaledonSingle-family homes along High Mountain Road
Pompton LakesThree rivers, old lake houses and flooded basements
Pompton PlainsAbout a quarter of homes heat with electricity

Heating and AC Repair Questions

What is considered a major repair for HVAC?

The big repairs are the parts the whole system is built around: a cracked boiler section or leaking boiler tank, a failed furnace heat exchanger, an air conditioner or heat pump compressor, and an outdoor or indoor coil that leaks. Circulator pumps, blower motors, gas valves and control boards sit in the middle. Igniters, flame sensors, capacitors, contactors, thermostats and zone valves are the small, common repairs.

What regular maintenance does HVAC need?

A hot water or steam boiler needs its burner cleaned and adjusted, the low water cutoff tested and the pressure or water level checked each heating season. A furnace needs a clean filter, a clean flame sensor and a check of the blower and venting. Central air and heat pumps need clean coils, a clear condensate drain and a check of the capacitor and electrical parts before summer.

Is a boiler more efficient than a furnace?

It depends on the models, not the type. A modern condensing boiler and a condensing furnace are both high efficiency, and an old cast iron boiler and an old furnace both waste fuel. Hot water heat holds steady temperatures and loses little through ducts, which is why many older Wayne homes kept their boilers. Steam systems are the least efficient of the group.

What is the average lifespan of an HVAC system?

Each part of the system ages on its own clock. Cast iron boilers outlast almost everything else, gas furnaces come next, and outdoor air conditioners and heat pumps wear fastest because they sit in the weather. How often it was serviced, how many times a basement flooded and whether the system was sized right matter more than the year on the label.

Why is my HVAC blowing cold air when the heat is on?

On a furnace, cold air at the vents usually means the burners never lit or shut off: a failed igniter, a dirty flame sensor, a tripped limit switch or a blocked condensate drain. On a heat pump it can be a defrost cycle, a stuck reversing valve or backup heat that never turned on. A thermostat set to fan On instead of Auto also blows room air between cycles.

Why did my heater stop working all the sudden?

Sudden stops usually trace to one part or one safety switch. On a boiler it is often the burner, the low water cutoff, a circulator pump or a zone valve. On a furnace it is the igniter, flame sensor, pressure switch or a control board. A tripped breaker, a dead thermostat battery or a service switch turned off by mistake can look the same.
Boiler, Furnace or AC Down?

Heating and cooling repair in Wayne and nearby towns. Call (973) 709-5323.

Call (973) 709-5323